AdBlue in the Diesel Tank in Kilnhurst: What Now?
All of it hinges on a single detail: if your engine has been run since the AdBlue went in — far more than anything else. Out in Swinton Bridge or here in Kilnhurst, an unrun engine must remain unrun. Ring 0333 366 0103 with the ignition and motor still off. Across Kilnhurst, that is typically emptied and flushed where it stands. When the engine has run, stop safely first, then turn it off. Step one remains unchanged, even if the work is bigger.
Further down: the cases our engineers meet, anywhere across South Yorkshire. Pick yours.
At the pump around Kilnhurst: AdBlue in a diesel
You are at the pump, the nozzle or the bottle still in your hand, and you have just noticed the cap you opened was the wrong one. Somewhere in Kilnhurst, then — JET, Shell, or anywhere else nearby.
In short: no better place to be to discover it. Still in the tank, with no fuel drawn onwards: that is where the AdBlue is.
What to do: do not get back in and start the car to clear the petrol pump. Phone us from the forecourt after the car sits in a space — the attendants will help push it — and save the bottle. Can't move the vehicle by the pump? Explosion-proof kit makes a busy forecourt safe, and so it can be drained where it is.
At home in Kilnhurst with AdBlue in your diesel tank
On the dash, a warning had been lit for days. A bottle bought at the garage, tipped in on the driveway — and it's only by the bin that the cap caught a second look. It happens on driveways just off Meadow View Road as commonly as anywhere.
The upshot: zero miles since leaves this nearly equal to finding it at the pump. AdBlue doesn't mix with diesel; it sinks to the bottom of your tank and waits there. Overnight does not change that.
Put the keys indoors overnight — or someone may take it off at breakfast — and phone us. Your driveway is where it is drained, be it in Kilnhurst or Piccadilly. The pumps are quiet enough to use outside a house after dark.
On the road in Kilnhurst with AdBlue in a diesel
Rough running, smoke, falling power or a glowing dashboard arrived a mile or two after the top-up. It might have been heading for Doncaster, under 10 miles away, or simply along Birdwell Road.
Put simply: the AdBlue has been sucked through your fuel system. It's been through the fuel filter and your lines and, the further you went, into your high-pressure pump and the fuel injectors. More driving, more restarts: deeper it goes.
Pull in somewhere safe — that is the first step — then turn it off. Service stations farther on are too far: from the M18, under 5 miles out of Kilnhurst, take the next junction. Starting it again to check achieves nothing — AdBlue never clears on its own. Call us and say how far you went.
AdBlue in the wrong tank of a hire, lease or company car
You have had this car barely a week. Unknown to you, the two inlets sit next to each other here — unlike your own car, which has none or keeps it elsewhere. It can happen to anyone, anywhere around South Yorkshire.
In short: one extra step on top of the cases above, which turn on whether it has run. Plenty of hire and company contracts want the owner to approve work on the car.
What to do: ring the hire firm or your fleet manager first, then us. That is faster settled before our engineers turn up than after. Stranded near St Thomas or outside Swinton (South Yorks) until someone replies, your vehicle remains turned off the whole time.
Not sure it was AdBlue in the diesel tank, Kilnhurst?
Sometimes the fair answer is "I think so". The bottle is lighter than it should be, there's a faint smell of ammonia round the filler, and you can't remember which cap you took off. Possibly it happened in a hurry at the school gates at Kilnhurst St Thomas' CofE Primary Academy, or on a friend's drive in Ryecroft.
The point: your engine is not harmed by a little AdBlue spilled on the outside. A diesel tank with AdBlue in it is another story. Turning on the vehicle won't tell you which, and if there is AdBlue in that tank it would draw it in.
What to do: treat it as if it got in. Don't start the vehicle. Phone and give the details: we'd rather find a tank free of AdBlue than empty one once your motor has been run.
What every AdBlue drain in Kilnhurst has in common
The work begins identically, whichever the situation. Wherever the car is — The High House's car park, a street by Swinton Community Library, a driveway, a filling station — the van gets there and asks about the liquid, the amount, plus if the motor has turned over. Answers set the job; the price follows by phone whilst no one has set off yet.
Then the tank is emptied and the fuel system flushed thoroughly, which matters more with AdBlue than with petrol: AdBlue crystallises and is corrosive to some of the metals in a fuel system, and so it does not rinse out on its own. Fresh diesel goes in after the fuel filter is flushed or replaced, and your car is finally checked. Not started? Then about half an hour once we are there is most jobs.
The final step is firing it up. Before our engineers go, it's tested to make sure it runs smoothly on fresh diesel. If it is caught soon, the vehicle very rarely has lasting damage, and the entire job happens where it is. You pay on the day, with nothing upfront, and get a VAT invoice and an engineer report for your insurer. Many insurance policies include misfuelling cover, and so it's worth checking yours whilst we are on the way.
About Kilnhurst, briefly
Kilnhurst is a village in South Yorkshire, situated on the banks of the River Don at an elevation of 51 metres. Kilnhurst lies approximately 8 miles from Doncaster and 145 miles from London, with nearby places including Piccadilly, Swinton, and Sandhill. Kilnhurst has a population of around 3006 people, predominantly living in semi-detached housing. Kilnhurst is characterized by its riverside setting, which has influenced its development over time.
AdBlue drains across South Yorkshire, Kilnhurst included
Kilnhurst is a village, and the same vans that cover it work the towns near it too, Swinton and Sandhill among them, across the S postcode area. Fastest of all: a S64 5 postcode to show where you stand.
No towing is needed, whether parked centrally in Kilnhurst or on a layby en route to Kilnhurst Ings Nature Reserve, so keep it where it is. Draining is done on the spot. Phone and check instead of guessing if you're close to Swinton Lock Activity Centre, near a boundary, or anywhere awkward to explain.
In one line: your situation
If it has not run, phone then keep it that way. Already run: stop, switch off then ring. Either way, Petrol in Diesel takes it from there in Kilnhurst and anywhere across South Yorkshire on 0333 366 0103.